Wetting Control in the Layered Polymer-silver Thin Film via Femtosecond Laser Microstructuring

Sofia Filippovna Umanskaya, Pavel Aleksandrovich Danilov, Seigey Ivanovich Kudryashov, Andrey Andreevich Rudenko, Andrey Alekseevich Ionin
Author affiliations

Authors

  • Sofia Filippovna Umanskaya Lebedev Physical Institute, Leninskiy prospect 53, 119991 Moscow, Russia<br /> and <br /> National Research Nuclear University MEPhI (Moscow Engineering Physics Institute),<br /> Kashirskoe shosse 31, 115409 Moscow, Russia
  • Pavel Aleksandrovich Danilov Lebedev Physical Institute, Leninskiy prospect 53, 119991 Moscow, Russia
  • Seigey Ivanovich Kudryashov Lebedev Physical Institute, Leninskiy prospect 53, 119991 Moscow, Russia;<br /> <br /> National Research Nuclear University MEPhI (Moscow Engineering Physics Institute), Kashirskoe shosse 31, 115409 Moscow, Russia; <br /> <br /> ITMO University, Kronverksky prospekt 49, 197101 Saint-Petersburg, Russia
  • Andrey Andreevich Rudenko National Research Nuclear University MEPhI (Moscow Engineering Physics Institute),<br /> Kashirskoe shosse 31, 115409 Moscow, Russia
  • Andrey Alekseevich Ionin Lebedev Physical Institute, Leninskiy prospect 53, 119991 Moscow, Russia

DOI:

https://doi.org/10.15625/0868-3166/29/1/13503

Keywords:

femtosecond laser, laser processing, femtosecond microfabrication, thin films, wettability

Abstract

Water wetting of a structured multi-layered thin film consisting of bottom silver and top polymer layers microstructured by femtosecond laser pulses was studied. The periodic trenches were ablatively produced on the top polymer layer of the film using 515-nm, 220-fs pulses of an ytterbium-doped fiber laser at different pulse energies and the repetition rate of 20 kHz. The topography of the structured film was observed by means of a JEOL 7001F scanning electron microscope and its water wetting angles were measured by side-view microscopic imaging. The wetting angle on the microstructured surface was 144°, comparing to 83° at the raw unstructured surface of the film.

Downloads

Download data is not yet available.

References

Jiale Yong, Qing Yang, Feng Chen, Dongshi Zhang, Umar Farooq, Guangqing Du and Xun Hou, J. Mater. Chem. A 2 (2014) 5499.

Anne-Marie Kietzig, Mehr Negar Mirvakili, Saeid Kamal, Peter Englezos and Savvas G. Hatzikiriakos, Journal of Adhesion Science and Technology 25 (2011) 2789.

D H Kam, S Bhattacharya and J Mazumder, J. Micromech. Microeng. 22 (2012) 105019.

[Boinovich, L.; Domantovskiy, A.; Emelyanenko, A.; Pashinin, A.; Ionin, A.; Kudryashov, S.; Saltuganov, P., ACS Applied Materials and Interfaces 6 (2014) 2080.

D Cristea, P Obreja, M Kusko, E Manea, R Rebigan Materials Science and Engineering, 26 (2006) 1049.

D.A. Zayarnyi, A.A. Ionin, S.I. Kudryashov, S.V. Makarov, A.A. Rudenko, E.A. Drozdova, S.B. Odinokov, Quantum Electronics 45 (2015) 462.

T. V. Baikova, P. A. Danilov, S. A. Gonchukov, V. M. Yermachenko, A. A. Ionin, R. A. Khmelnitskii, S. I. Kudryashov, T. T. H. Nguyen, A. A. Rudenko, I. N. Saraeva, T. S. Svistunova, and D. A. Zayarny, AIP Conference Proceedings 1874 040052 (2017).

D Pavlov, S Gurbatov, SI Kudryashov, PA Danilov, AP Porfirev, SN Khonina, OB Vitrik, SA Kulinich, M Lapine, AA Kuchmizhak, Optics Letters 44 (2019) 283.

F. Gentile, G. Das, M. Coluccio, F. Mecarini, A. Accardo, L. Tirinato, R. Tallerico, G. Cojoc, C. Liberale, P. Candeloro et al., Microelectronic Engineering 87 (2010) 98.

F. De Angelis, F. Gentile, F. Mecarini, G. Das, M. Moretti, P. Candeloro, M. Coluccio, G. Cojoc, A. Accardo, C. Liberale et al.,Nature Photonics 5 (2011) 682.

Zhizhchenko, A., Kuchmizhak, A., Vitrik, O., Kulchin, Y., & Juodkazis, S., Nanoscale, 10 (2008) 21414.

Downloads

Published

18-03-2019

How to Cite

[1]
S. F. Umanskaya, P. A. Danilov, S. I. Kudryashov, A. A. Rudenko, and A. A. Ionin, “Wetting Control in the Layered Polymer-silver Thin Film via Femtosecond Laser Microstructuring”, Comm. Phys., vol. 29, no. 1, p. 71, Mar. 2019.

Issue

Vol. 29 No. 1 (2019)

Section

Papers

License

Communications in Physics is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Copyright on any research article published in Communications in Physics is retained by the respective author(s), without restrictions. Authors grant VAST Journals System (VJS) a license to publish the article and identify itself as the original publisher. Upon author(s) by giving permission to Communications in Physics either via Communications in Physics portal or other channel to publish their research work in Communications in Physics agrees to all the terms and conditions of https://creativecommons.org/licenses/by-sa/4.0/ License and terms & condition set by VJS.

Most read articles by the same author(s)

Similar Articles

<< < 7 8 9 10 11 12 

You may also start an advanced similarity search for this article.